Weber Saint-Gobain - Official website of the company

weberep 332 FR

weberep 332 FR
weberep 332 FR

Product benefits

  • Non-shrinking
  • Fast-hardening
  • Good resistance to sea water and to high-sulfate water

Non shrink thixotropic fine repair mortar with fiber

weberep 332 FR is a ready-to-use mortar composed of silica sand (reconstituted grain size range), special cement, microsilica, fibers, and additives that provide specific properties: non shrinking, thixotropic, high strength, high adhesion, compactness. Its very closed grain size slows down carbonation.

Product Features

Scope of use

Repair of concrete surfaces, representing honeycombing and spalling of concrete surface.

Characteristics

Appearance

Grain size
Yield
Mortar density
pH
Thickness
Flexural strength
Compressive strength

Adhesion on concreteat 28 days

Grey Powder

0 to 1.5 mm
13 lit. mortar / 25 kg bag
2.05 - 2.25
12
2 to 20 mm in one coat
8 MPa* at 28 days
50 MPa at 28 days

> 1.5 MPa

*7 MPa for Lebanon

Consumption

Approximately 2 kg/m2 per mm thickness.

Applicable standards

ASTM C942
ASTM D4541
BS -1542

Storage

12 months after manufacturing date in original and non-open packaging, under cover, in dry condition, away from humidity, protected from extreme temperatures and direct sunlight.

Documentation

Send or download the documentation

You can either send the documentation to an email address, or download it.

Instructions for use

Product preparation

Add 4.5 lit. of clean water (3.25 to 3.75 lit. for Lebanon) to a 25 kg bag weber.rep 332 FR. Mix until a homogeneous mortar is obtained. weber.rep 332 FR must be used within one hour from mixing. Re-mixing with an extra amount of water is forbidden.

Product application

Surface preparation

This mortar may be applied to all sound substrates: concrete,masonry, rock and similar materials. Remove damaged concrete and laitance by jack-hammering, cold-chiseling, or running a concrete plane to get a sound, rough surface. The area must be surrounded by clean edges. Do not create feather edge. The surface must also be free from any trace of grease or oil. Remove dust from all surfaces to be repaired. Saturate the surface with water by opiously spraying just before application, and, if possible, 6 hours before application as well.

Product application

Apply weber.rep 332 FR with a trowel and press hard on the surface. Run a mason’s board across repaired surface, and smooth it. Apply a curing compound onto the surface as soon as application is finished to protect from wind and sunshine. Ideal application temperature is between + 5ºC and + 35ºC. If the application temperature is higher than 35 ºC, make sure to use cool water to keep the mixed mortar temperature below 30 ºC.

Environmental and Safety

Safety precautions

The product contains cement powders which, when mixed with water, release alkalis that could be harmful to the skin. It is preferable that the application be done in a ventilated area, and to wear protective gear for hands, eyes and respiratory system and to avoid breathing of the dust. Splashes on the skin should be washed away by cleaning with soap and water. In case of contact with eyes, wash thoroughly with clean water. If swallowed, do not induce vomiting, in both cases seek medical attention. The product is non-flammable.

Disclaimer

While the company guarantees its products against defective materials, the use and application of these products are made without guarantee since the conditions of their application are beyond its control. It is recommended to verify with the company that the product is suitable for the intended use, and that this Data Sheet version is the latest one. The company may modify it without prior notice. Technical characteristics are listed for guidance only. For more information, please contact the company’s office in your location.

Note

The information included on this Technical Data Sheet is the sole property of SODAMCO Holding. The unauthorized disclosure, use, dissemination or copying (either whole or partial) of this data sheet or any information it contains, is prohibited and subject to legal pursuit.

Available packaging

Lebanon25 kg
Syria25 kg
Jordan25 kg
KSA25 kg
UAE25 kg
Qatar25 kg
Kuwait25 kg
Oman25 kg